Evaluation of Results from Occupational Tuberculin Skin Tests --- Mississippi, 2006

Persons using assistive technology might not be able to fully access information in this file. For assistance, please send e-mail to: [email protected]. Type 508 Accommodation and the title of the report in the subject line of e-mail.

In October 2006, the National Institute for Occupational Safety and Health (NIOSH) received a request for a health hazard evaluation from a fire department in Mississippi. In June 2006, the fire department had administered two-step tuberculin skin tests (TSTs) and determined that nine firefighters tested positive for tuberculosis (TB) infection. Local investigation had identified no source of TB infection. The NIOSH evaluation was conducted to 1) determine whether TB transmission was occurring among department firefighters, 2) assess the accuracy of positive TST results, and 3) make recommendations regarding administration of future fire department TB-testing programs. This report describes the results of that evaluation, which indicated that all nine firefighters had false-positive TST findings, likely caused by errors in interpretation of the test results. These results highlight the importance of conducting TB testing only when indicated by TB risk assessment and following CDC guidelines to avoid errors in TST administration and interpretation that might result in unnecessary medical evaluation and follow-up (1).

The fire department had instituted TSTs in June 2006 to comply with National Fire Protection Association guidelines that recommend annual TSTs for all firefighters. Testing was conducted by the same local hospital that administered occupational medical examinations for the fire department. Nine (9%) of 101 firefighters had positive TST results, using the Mississippi state criteria of >10 mm induration as indicative of a positive test for TB infection.*

The nine firefighters were evaluated by interview for symptoms consistent with TB disease, and chest radiographs were administered by Mississippi Department of Health District 6 medical personnel; no cases of TB disease were identified among the firefighters. All nine firefighters had latent tuberculosis infection (LTBI) diagnosed and were evaluated for isoniazid therapy. Five of the nine firefighters began isoniazid therapy; the four others either refused therapy or stopped soon after starting. No source of TB exposure was identified. However, because no reason for the positive TSTs among the firefighters was identified, the community continued to be concerned about possible ongoing TB transmission.

In October 2006, the fire department asked NIOSH to conduct a health hazard evaluation. State and district TB program personnel told NIOSH that the annual incidence of TB disease in the area served by the fire department was 2.5 cases per 100,000 population during 2005--2006. In comparison, annual incidence in the state overall was 3.9 per 100,000, and U.S. incidence was 4.6 per 100,000 (S Quilter, MS, Mississippi State Dept of Health, personal communication, 2007).

The nine firefighters with positive TST results were interviewed by NIOSH personnel to assess their personal and occupational risk factors for TB exposure and infection; no risk factors for TB were identified. No firefighters were foreign born, and none had known or suspected past contact with a person infected with TB disease. Foreign travel among the nine firefighters was limited to brief vacations in resort areas or remote military service. No firefighters reported a history of positive TSTs.

Four months after the two-step TSTs were administered, on October 27, blood samples were collected from all nine firefighters for QuantiFERON^®-TB Gold (QFT-G) (Cellestis Limited, Carnegie, Victoria, Australia) testing to measure immune reactivity to Mycobacterium tuberculosis. All QFT-G test results from blood samples collected from the nine firefighters were negative.

Medical staff members at the local hospital who administered the firefighter two-step TSTs were interviewed to compare their protocols with CDC guidelines (1,3). Three of the nine firefighters had positive results after their first TST. The other six firefighters had negative results after placement of their first TST; however, among these six firefighters, results from their first TST had not been read until 9--21 days after placement, instead of the recommended 48--72 hours, which likely accounted for their interpretation as negative TSTs. The second TST in these six firefighters was read within 48--72 hours and interpreted as positive. Interviewers further determined that hospital staff members had misinterpreted application of the state's alternate two-step schedule. According to state officials, this schedule is to be used primarily for home--health-care patients and nursing-home residents to lower costs (i.e., by reducing visits from four to three through reading the first test and placing the second test on the same visit) but still allow detection of "booster" effects; the schedule is not intended for use with employee surveillance programs (S Quilter, MS, Mississippi State Dept of Health, personal communication, 2007).

Other TST irregularities occurred. Medical personnel read TST induration along the vertical axis of the forearm, instead of the horizontal axis. In addition, the hospital had traditionally used Tubersol^® brand of tuberculin for TSTs. However, in 2006, purchasing officials switched to Aplisol^® brand of tuberculin, which was used to administer the two-step TSTs to the firefighters. CDC guidelines recommend the consistent use of one brand of tuberculin (1); changes in tuberculin antigen have resulted in misreading of results that were erroneously reported as a health-care--associated outbreak (4). These firefighters were the first occupational group to receive TST in this specific hospital department since the change to Aplisol was instituted. TSTs conducted among employees in another hospital department using Aplisol revealed no increase in positive test results.

To explore the effects that different tuberculin brands and interpretation errors might have had in the false-positive TST results and to make recommendations regarding future TSTs for these firefighters, seven of nine available firefighters were retested with Tubersol brand tuberculin as part of the NIOSH evaluation; one firefighter was no longer employed at the department, and one refused testing. All seven firefighters tested negative. Investigators concluded that the false-positive results from the hospital-administered TSTs likely were the result of interpretation errors resulting from the change in tuberculin used and inexperience in interpreting TST results. As a result of the NIOSH evaluation, the five firefighters who were still receiving isoniazid for LTBI discontinued their medication. Because the hospital-administered TSTs were false-positives, these firefighters are eligible to receive future TSTs and should not be deferred from future testing on the basis of having a previous positive test result.

Reported by: EH Page, MD, RJ Driscoll, PhD, Div of Surveillance, Hazard Evaluations, and Field Studies National Institute for Occupational Safety and Health; JD Gibbins, DVM, EIS Officer, CDC.

Editorial Note:

Occupational groups such as firefighters, health-care workers, and military personnel often receive periodic TB tests because of potential occupational exposure to TB disease. An estimated 1.1 million firefighters in the United States are at risk for TB exposure while performing first-responder duties (5). In addition, firefighters live in close quarters while on duty, and living conditions might facilitate rapid spread of TB among coworkers. Therefore, the National Fire Protection Association recommends an annual TST for firefighters (6).^† Fire department compliance with this consensus-based standard is not legally required; however, many departments use this guidance to develop their occupational examination requirements. CDC guidelines recommend that a facility TB-risk assessment be conducted annually for groups at risk for TB infection and that frequency of TB testing be based on the results of that assessment (1).

The investigation described in this report highlights the importance of conducting TB risk-assessment and treatment programs according to CDC guidelines and using targeted testing at a frequency based on a TB risk assessment. When TST administration is indicated, administrators should 1) interpret TST results 48--72 hours after placement to avoid potential false-negative results; 2) for routine, serial testing, avoid switching brands of tuberculin, which might create potential interpretation errors and false-positive results; 3) interpret test results in millimeters along the horizontal axis of the forearm to help ensure consistency among TST readers; 4) follow manufacturer guidelines for storage and use of tuberculin products; 5) document lot number, brand name, and manufacturer of tuberculin; and 6) receive training to distinguish induration from erythema. Finally, if higher numbers of positive TST results than expected are encountered, potential causes of false-positive results should be explored concurrent with the evaluation of patients for TB disease. False-positive TST results increase medical costs and expose persons to unnecessary medication that can have serious side effects.

The findings in this report are subject to at least one limitation. Five firefighters were still receiving isoniazid therapy for LTBI at the time of QFT-G testing. The effect of isoniazid prophylaxis on T-cell response and gamma-interferon (INF-gamma) production, which is the basis for the QFT-G test, is equivocal (7). Concurrent isoniazid therapy might have played a role in the negative test results of these firefighters; however, their low risk for TB infection and subsequent negative TST results using Tubersol provide strong evidence that these firefighters had never been infected with M. tuberculosis.

QFT-G is an alternative to TSTs in TB testing programs. Advantages of QFT-G include the following: 1) greater specificity than TSTs can be achieved with similar sensitivity; 2) test results are not affected by previous bacille Calmette-Guérin vaccination against TB; 3) two-step testing is not required; and 4) only a single office visit is required, with results available in 24 hours (8). A discussion of the advantages and disadvantages of using QFT-G has been published (9).

As a result of the pseudoconversions described in this report, the fire department strengthened its infection-control and respiratory-protection programs. Health-care professionals should conduct periodic training and evaluation of their TB testing programs to ensure that CDC guidelines are followed.

This report is based, in part, on contributions by A Turk, R James, MD, Mississippi Dept of Health, District 6; BP Bernard, MD, TR Hales, MD, AL Tepper, PhD, E Galloway, Div of Surveillance, Hazard Evaluations, and Field Studies; B MacKenzie, Div of Applied Research and Technology, National Institute for Occupational Safety and Health, CDC.

References

Use of trade names and commercial sources is for identification only and does not imply endorsement by the U.S. Department of Health and Human Services.

References to non-CDC sites on the Internet are provided as a service to MMWR readers and do not constitute or imply endorsement of these organizations or their programs by CDC or the U.S. Department of Health and Human Services. CDC is not responsible for the content of pages found at these sites. URL addresses listed in MMWR were current as of the date of publication.

Disclaimer All MMWR HTML versions of articles are electronic conversions from ASCII text into HTML. This conversion may have resulted in character translation or format errors in the HTML version. Users should not rely on this HTML document, but are referred to the electronic PDF version and/or the original MMWR paper copy for the official text, figures, and tables. An original paper copy of this issue can be obtained from the Superintendent of Documents, U.S. Government Printing Office (GPO), Washington, DC 20402-9371; telephone: (202) 512-1800. Contact GPO for current prices.